四全自动槽电解式模具清洗机
  • 四全自动槽电解式模具清洗机

  • 产品分类:电解模具清洗机系列

  • 产品品牌:

  • 会员价格:¥450000.00

  • 发布日期:2025-5-4 9:28:41

  • 产品简介:

    Electroanalysis ultrasonic mould cleaner operational instruction 一, 电解超声波(塑胶模具)清洗机清洗工艺描述 Electroanalysis ultrasonic(Plastic mould)cleaner process description 1,电解超声波系统是由超声波发生系统,电解电路系统,循环过滤系统,控制系统,专用的金型清洗液和水性防锈剂组成。Electroanalysis ultrasonic system concludes ultrasonic occurrence system, electroanalysis circuit system, cycle filtration system, control system, special cleaning liquid and waterborne anti – rust. 1,电解洗净系统是向金属表面发射气体,用桑拿的效果除去金属表面的脏物,不纯物,还可以完全除去模具上的锈斑,积炭,瓦斯气体,树脂成分,湿气,油污,通过超声波的震动污垢剥离漂浮起来,金属模具防在阴极,即使相当小的角落里的污垢也能完全去除。Electroanaly is cleaning system: remove the dirt of the surface with the sauna effectiveness by spraying the gas towards the metal surface, it also can completely remove the rust spots, carbon deposit gas, resins, humidity and oil stains on the surface of the mould. The principle of this system is to peel off the dirt and let them floating by ultrasonic shaking to remove the dirt even though the dirt is in the relatively small corners. 2,将金属还原到原有的钢绿色,恢复金属原来的绮丽。Let the metal recover to intrinsic green 3,即使是复杂的形状也可以去除污垢。Can remove the dirt even for the complicated shapes mould 4,能完全确实的洁净去污。Can remove the dirt completely 5,有良好的除锈防锈效果。Have good anti-rust effect. 6,比人工清洗要节约一小时的时间。Can save 1 hour than manual work 7,比使用有机溶剂更环保更安全。More environmental and safe than using organic solvent 8,大大的降低了洗净后不良率。Obviously reduce the rejection rate after cleaning 工艺;Process 1,金型洗净6-15分钟_____Cleaning for 6-15 minutes 2流水洗净3分钟_________Cleaning for 3 minutes with running water 3防锈工程3分钟。Antirust engineering for 3 minutes 设备用途:用于精密塑胶模具,模块,模件,模仁,镶针,镶件,去高温积碳,去硫化物,瓦斯气体,油污,锈斑的清洗。 Equipment application: applied to precision plastic mould, module,insert, Pin,clean high temperature carbonium, clean sulfide, gas, oil dirt and rust spots cleaning2,电解超声波模具清洗机原理:Electroanalysis ultrasonic mould cleaner principle 电解超声波是由电解超声波清洗槽,喷淋清洗槽,超声波系统,电解电路系统,电极,托盘,过滤循环系统,定时装置,面板电器开关装置组成。 Electroanalysis ultrasonic includes electroanalysis ultrasonic wash tank, spray wash tank, ultrasonic system, electroanalysis circuit system, electrode, tray, filtration cycling system, timing setting and panel switch. 1,电解清洗是利用电解作用将金属表面的污垢去除的清洗方法;电解是在电流作用下,物质发生化学分解的过程.在电解过程中,金属表面的污垢开始脱落,在超声波的冲击下加速了剥离,在金属表面沾有动植物油,矿物油,锈迹,锈斑,积炭,氧化层.用电解的方法把这些污垢去除叫电解脱脂。Electroanalysis cleaning is a method by electroanalysis function to remove the dirt from metal surface; electroanalysis is a process which the matter with chemical decomposition. The dirt of the metal surface fall off during the electroanalysis, and accelerate the peel off speed with the concussion from ultrasonic. The electrolytic method is used to remove the propagation oil, mineral oil, rust spots, oxide layer from metal surface which is called electroanalysis degrease. 当电流通过含有特殊配方的电解质的水溶液时,在电解槽的正极附近产生氧气,负极产生氢气.把要清洗的金属部件放入电解槽的正极(清洗篮),在电解过程中,在金属表面会有细小的氢气产生,这些小气泡促使污垢从金属表面剥离。 The anode of the electrobath will produce Oxygen and cathode will produce the hydrogen when there is current pass water solution with special electrolytical mixture. Put the metal parts into the anode of the electrobath(clean basket), there will produce small hydrogen on the metal surface, and these small air bubbles will prompt the dirt peel off from metal surface. 2,超声波清洗是利用28KHZ的高频电源,使换能器由电能转换机械能的过程,在这过程中换能器向清洗槽溶液传递巨大的能量,在液体中产生正压和负压区,形成数以万计的空穴气泡,在不断的形成爆炸,冲击被清洗金属物表面,使金属表面的污垢快速脱离。 The ultrasonic cleaning use the 28KHZ high frequency power supply and the transducer by converting electric energy to mechanical energy. In the transducer to the cleaning solution tank transfer huge energy, produce positive pressure and negative pressure zone in the liquid, tens of thousands of cavitation bubbles formation, in continuous form into the explosion, the impact is cleaning the metal surface and quickly out of the dirt on the surface of the metal.3,循环系统是由耐腐蚀的广州小巨人磁力泵,过滤器组成自循环,让清洗脱落的污垢迅速被过滤棉芯隔离,减少液面漂浮物.同时可加速溶液的电解。净化溶液,提高溶液的利用率。 Circulatory system is by the corrosion of the little giant magnetic pump, filter self circulation, let washing off the dirt quickly filtered cotton core isolation, reduce the liquid surface floater. Also can accelerate the solution electrolysis. Purification solution, improve the utilization rate of solution.

  • 产品订购热线:13828757635
产品简介:

爱洁乐全自动模具清洗机技 术 规 格

 

一、设备名称:塑胶模具零部件全自动清洗机

 

二.型号:ADL-40120LT(120升)(详见设备结构示意图)

 

三、设备用途:清洗模板,模仁,模芯,顶针,镶件,镶块等等。

用于清洗工件上的瓦斯气体、油污及其它污染物、锈迹。                           

四、设备能力:       

1)   每天可连续2班工作,每班8小时。

2) 清洗节拍:30分钟/篮 每篮可装1个(按最大综合尺寸:700X300X300mm算)

   

 

五、清洗后不留污物、干净干燥。

 

六.清洗工艺:   清洗工艺流程安排:进料(工位一)→电解超声波清洗(工位二)→

(工位三)→喷淋清洗(工位四)→超声波防锈(工位五)→热风干燥(工位六)→出料(工位七)。

 

序号

工序方法

工序说明

介质

加热

温度

过滤精度

储液箱

1

电解超声波清洗

2400W

40KHZ

电解清洗剂(水剂清

洗剂)

 

电加热

6KW

 

60-70℃

20µ

 

 

 

 

 

 

2

喷泳清洗

 

纯水

 

60-80℃

 

3

超声波漂洗

1800W

40KHZ

防锈剂

 

50-70℃

 

4

热风烘干

 

热风

电加热

12KW

80℃

 

 

 

                                                 

 

七.设备主要技术要求:

7.1 结构组成

该清洗机主要由超声波发生器、换能器、喷淋槽、清洗槽、漂洗槽、烘干槽循环过滤系统、自动温控加热系统、进出料小车、机械手、烘干系统、机架、控制面板、控制系统和全封闭外罩等组成。

 

7.2 设备描述                                        

该清洗机是全自动全封闭超声波清洗系统,清洗过程由微机控制,4个由不锈钢材质制作的喷淋槽、超声波清洗槽、漂洗槽、红外线烘干装置组成的一条连续工作的装置。操作者将装有工件的清洗篮放置在进料小车上,机械手将清洗篮依次送往各工序段,对工件进行一系列清洗烘干后,将清洗好的工件送到出料小车上,操作者在同一进出口处将工件卸下。整个清洗机烘干机全封闭,装有可拆卸的观察检修门,缸盖采用可移动式缸盖,盖喷淋清洗槽,烘干槽,具体结构见附图和以下的说明。

 

7.3设备主要技术要求:

 

    7.3.1 第一槽:电解超声波清洗槽   

内槽尺寸:800×400×500 (L×W×H mm)

超声功率:2400W (底震式超声波震动板,48套日本NTK换能器)

超声频率:40KHZ

超声波发生器采用目前国际上先进的他激式发生线路,具备超声波功率无级调整、超声波频率微调、扫频超声波工作方式控制等功能,每套超声波装置均可以单独控制;

槽体电加热功率:1KW×6=6KW,常温—100℃范围内可调,恒温控制.

设循环过滤系统,由不锈钢泵(CHL2-20)不锈钢过滤器等组成,过滤精度20μ。

清 洗 液:电解水基清洗剂+市水

 

           7.3.2  第二槽:喷泳清洗槽

内槽有效尺寸:800×400×500(L×W×H mm)

喷淋系统由不锈钢喷淋泵(CHL4-40)和管路等组成;

喷淋管左右各二根,8支喷嘴/根;喷淋压力:2-5bar;

喷泳采用2.2KW,不锈钢泵(粤华牌)。

工作原理:采用1寸气动电磁阀进水,当水加到溢流口时,自动停止加水。

喷泳是采用自循环方式射流喷洗。

喷淋槽设有溢流口,喷用时溢出的水流到排水管。

工作液体:市水

 

第三槽:超声波防锈槽

 内槽尺寸:800×400×500 (L×W×H mm)

超声功率:1800W (底震超声波震板,36套日本NTK换能器)

超声频率:40KHZ

超声波发生器采用目前国际上先进的他激式发生线路,具备超声波功率无级调整、超声波频率微调、扫频超声波工作方式控制等功能,每套超声波装置均可以单独控制;

设有溢流口;进水口、排水口。

电加热功率:1KW×4=4KW、恒温控制;

设置自循环过滤系统,由不锈钢泵(CHL2-20)不锈钢过滤器等组成,过滤精度5μ。

清 洗 液: 防锈剂+市水

 

7.3.3 第四槽:热风烘干槽                      

内槽尺寸:800×400×400 mm

槽体外贴保温棉,槽底设置进气口,槽顶设回风口、热风内循环。

采用耐热运风风机。

 

网上采购:
姓名:
*
手机或电话:
*
邮箱:
*
采购意向描述:
*
请填写采购的产品数量和产品描述,方便我们进行统一备货。
验证码:
换一组
相关产品
产品评论
 
  • 该产品没有收到任何评价!

验证码:
看不清楚?点击换张图片